Sanyo CG1411 User Manual Page 47
- Page / 100
- Table of contents
- TROUBLESHOOTING
- BOOKMARKS
Rated. / 5. Based on customer reviews
Combustion lamp flashes
Wire misconnection
Amp. current is high
Amp. current is low
Initial
check 1 normal
Power Supply
Troubleshoot
Operation starts
Operation stops
1
2
3
4
3
6
8
7
7
Flap motor
E
2
P ROM read fail
Coil temp thermistor fail
Operation lamp flashes
Room temp thermostat fail
Combustion lamp flashes
Indoor fan
ON
NO
YES
NO
NO
NO
NO
YES
YES
YES
YES
ON LL
Operation lamp light
Reversing valve
ON
ON
Compressor ON
Initial
check 2 normal
Gas
combination valve &
circuit normal
Room temp.
(lower than set temp.)
9
9
a
Combustion motor (0 or 40 sec. after)
(80 sec. after)
(3 sec. after)
(more than 19A 2 sec. after)
(more than 17A 8 sec. after)
ON
10
11
12
Proportional control valve
ON
13
Solenoid valve GV1 ON
14
Solenoid valve GV2 ON
Solenoid valve GV1
OFF
Solenoid valve GV2
OFF
15
Ignitor ON
Combustion lamp ON
Indoor fan OFF
Compressor OFF
Solenoid valve GV1
OFF
Solenoid valve GV2
OFF
Proportional control valve OFF
Combustion lamp OFF
Ignitor OFF
Ignitor OFF
16
2
ON/OFF valve ON
ON/OFF valve 2 ON
Fan speed: Set speed
17
11
8
17
b
c
8
Fan speed: Set speed
Proportional controlled
combustion
3 min. timer
count-up
NO
YES
Initial check 3
normal
NO
YES
Thermistor 1, 2
normal
Operation lamp light
OFF
Indoor fan OFF
Flap motor
Compressor
Reversing valve
Operation lamp
OFF
Lamp flashes
OFF
OFF
ON/OFF valve V2
ON/OFF valve V1
(3 sec. after from )
OFF
Combustion motor
OFF
valve PV
Proportional control
OFF
Solenoid valve GV1
OFF
Solenoid valve GV1
(60 sec. after)
OFF
Solenoid valve GV2
OFF
valve PV
Proportional control
OFF
OFF
LD 2345
LD 2345
LD 2345
NO
NO
LD 2345
NO
NO
YES
YES
YES
Combustion motor
rev. normal
Flame sensor
circuit normal
11
NO
YES
Detect flame
(higher than 1µA)
NO
YES
Indoor coil temp.
(lower than 32°C)
NO
YES
(30 sec. after)
Thermistor-1
(higher than 47°C)
NO
YES
Safety device works
NO
YES
Room temp.
(higher than set temp.)
NO
YES
Thermistor-1
(higher than 42°C)
Flame sensor failure
: light off
NO
YES
First
Thermal fuse bimetal
thermostat normal
NO
YES
First
Combustion lamp flashes
LD 2345
LD 2345
LD 2345
C
(12 sec. after)
(15 sec. after)
(3 sec. after
from )
a
NO
YES
Combustion
continues more than
4 min.
LD 2345
LD 2345
LD 2345
LD 2345
Thermistor-1
higher than (185°F 85°C)
Thermistor-2
higher than (149°F 65°C)
Combustion lamp OFF
Combustion motor
(60 sec. after)
OFF Combustion motor
(60 sec. after)
OFF
Solenoid valve GV2
OFF
Solenoid valve GV1
OFF
Proportional control
valve PV
OFF
c
ON/OFF valve failure
Solenoid valve GV2
OFF
Solenoid valve GV1
OFF
Proportional control
valve PV
OFF
5
LD 2345
Combustion motor
(60 sec. after)
OFF
c
Reversing valve failure
Solenoid valve GV2
OFF
Solenoid valve GV1
OFF
Proportional control
valve PV
OFF
4
Combustion motor
(60 sec. after)
OFF
Solenoid valve GV2
OFF
Solenoid valve GV1
OFF
Proportional control
valve PV
OFF
NO
YES
Less than 3 times
NO
YES
Thermistor-1
(lower than 122°F 50°C)
NO
YES
NO
YES
Thermistor-2
(lower than 131°F 55°C)
10 min. passes
from
b
17
LD 2345
Combustion motor
(60 sec. after)
OFF
c
Solenoid valve GV2
OFF
Solenoid valve GV1
OFF
Proportional control
valve PV
OFF
Combustion lamp OFF
Thermistor-1
higher than (149°F 68°C)
Thermal fuse
bimetal thermostat failure
ON/OFF valve V2
ON/OFF valve V1
(3 sec. after from )
OFF
OFF
C
ON/OFF valve V2
ON/OFF valve V1
(3 sec. after from )
OFF
OFF
Compressor
Reversing valve
OFF
OFF
C
Combustion motor
(60 sec. after)
OFF
Solenoid valve GV2
OFF
Solenoid valve GV1
OFF
Proportional control
valve PV
OFF
Combustion lamp OFF
: light on
9-2. Heating
9-2-1. Starting Flowchart
43
9-2-2. Stopping Flowchart
Operation starts
Operation lamp Light OFF
Operation lamp Light OFF
Compressor OFF
Indoor fan OFF
Solenoid valve GV1 OFF
Solenoid valve GV2 OFF
Proportional control valve OFF
On/Off valve V1 OFF
On/Off valve V2 OFF
Reversing valve OFF
Combustion motor OFF
(180 sec.
after)
(60 sec.
after)
- GAS HEATER AIR CONDITIONER 1
- IMPORTANT! 2
- Please Read Before Starting 2
- Table of Contents 3
- 1. OPERATING RANGE 5
- 2. SPECIFICATIONS 6
- 2-2-1. Indoor Unit 8
- 2-2-2. Outdoor Unit (1) 9
- 2-2-2. Outdoor Unit (2) 10
- 2-3-1. Indoor Unit 11
- 2-3-2. Outdoor Unit 12
- 3. DIMENSIONAL DATA 13
- 3-1-2. Outdoor Unit 14
- 3-2. Internal Components 15
- 3-2-2. Outdoor Unit 16
- 3-3. Major Components 17
- (3) Main Burner 18
- Type: Ribbon Burner 18
- (4) Combustion Blower 18
- (5) Refrigerant Heater 19
- 4. REFRIGERANT FLOW DIAGRAM 20
- 5. PERFORMANCE DATA 21
- 5-3. Cooling Capacity 23
- 5-4. Heating Capacity 24
- 6. ELECTRICAL DATA 25
- (1) Indoor unit KGS1411 26
- (2) Outdoor unit CG1411 27
- 4FF4B10002710-2 28
- 7. INSTALLATION INSTRUCTIONS 29
- Min. 6" (15 cm) 30
- Valve side 30
- Min. 10" 30
- 7-3-1. Mounting on a Wall 32
- 8. FUNCTION 33
- 8-1-3. Combustion Control 34
- 8-2. Cooling 35
- 8-3. Heating 37
- 8-3-2. Refrigerant Control 38
- 8-7. Freeze Prevention 44
- 8-8-1. Indoor Unit 45
- 8-8-2. Outdoor Unit 45
- 9. OPERATION FLOWCHARTS 46
- 11. POINTS TO DIAGNOSE 54
- 11-3-1. Components 55
- 11-3-2. Indoor Unit 56
- 11-3-3. Outdoor Unit 56
- 12. TROUBLESHOOTING 57
- Start of Operation) 58
- ●● ●● ●● 63
- ●● ● ●● ●● 63
- ●● ● ●● ● 64
- ●● ● ● ●● 64
- ●● ● ● ● 64
- ● ●● ●● ●● 65
- ●● ● ● ●.” 65
- ● ●● ●● ● 66
- ● ● ●● ●● 66
- ● ● ●● ● 66
- Outdoor PCB 69
- 13-2. Refrigerant Recovery 70
- 13-5. Refrigerant Charging 71
- INSTRUCTION MANUAL 73
- KGS 1411 + CG1411 73
- APPENDIX 73
- Operating Instruction 74
- Installation Instruction 74
- Contents 75
- Product Information 75
- Alert Symbols 75
- Features 76
- Installation Location 77
- Electrical Requirements 77
- Safety Instructions 78
- OI-202-07EG 79
- IMPORTANT 80
- SET TEMP 81
- Remote Control Unit 82
- OI-202-11EG 83
- Using the Remote Control Unit 84
- Mounting the Remote 85
- Control Unit 85
- OI-202-13EG 85
- Operation with the Remote 86
- OI-202-15EG 87
- 2. Manual Operation 88
- OI-202-16EG 88
- 3. Adjusting the 89
- Fan Speed 89
- 4. Fan Only 90
- 5. Night Setback Mode 90
- OI-202-18EG 90
- OI-202-19EG 91
- Special Remarks 92
- Using the 12-Hour ON and OFF 93
- Using the 1-Hour OFF Timer 94
- OI-202-23EG 95
- OI-202-24EG 96
- OI-202-25EG 97
- Care and Cleaning (continued) 97
- Troubleshooting 99
- Tips for Energy Saving 99
- Operating Range 99
- For Parts or Service Contact 100
Related products and manuals for Heat pumps Sanyo CG1411
Heat pumps Sanyo KH2442 User Manual
(202 pages)
(202 pages)
Heat pumps Sanyo CH1822 User Manual
(17 pages)
(17 pages)
© 2020, manymanuals.com. All rights reserved. | 1.452 s |
Manymanuals.com
Manymanuals.de
Manymanuals.fr
Manymanuals.it
Manymanuals.pl
Manymanuals.cz
Manymanuals.es
Manymanuals-pt.com
Comments to this Manuals